加载中…
个人资料
水泵知识
水泵知识
  • 博客等级:
  • 博客积分:0
  • 博客访问:28,291
  • 关注人气:1
  • 获赠金笔:0支
  • 赠出金笔:0支
  • 荣誉徽章:
相关博文
推荐博文
谁看过这篇博文
加载中…
正文 字体大小:

雨季提灌机械保养四注意

(2009-04-16 08:07:32)
标签:

杂谈

    一、对于停用的离心泵,要把泵和胶管提出机井,放净泵内和胶管内的存水。然后,按技术要求,认真检查水泵的叶轮、轴承、口杯等零件,若有损坏应及时更换。轴承用汽油洗净,涂上黄油,再安装好。水泵的底阀、弯管等铸铁件,生了锈的要除锈,然后再涂上黄油,放在干燥处保存,以备冬春再用。
  二、深井泵。深井泵若暂时不用,可每隔7~10天启动运行半小时,以防电动机、起动器等电器设备受潮和水泵的转动部位锈死。如果停用的时间较长,就应把水泵从井中提出来,进行维修、除锈、涂油及换件,组装后入库保存。
  三、电动机。电动机长期不用容易受潮,因而应从井上拆卸下来,拉回室内,把电动机外壳上的污物擦拭干净。对机心部分的完好状况,要按技术要求进行检查,若有磨损的零件,要维修或换件,待符合技术要求后,再入库保存。若短期停用,可在电动机和起动器上,搭上油毛毡或塑料布,做好防雨、防潮及防尘等工作。
  四、柴油机。夏秋雨季,放置在河边、井旁暂不使用的柴油机,要及时抬到室内。按技术要求进行一次彻底地检查、维修、换件、涂油,使各部位保持完好的技术状态。然后垫高存放,以备冬春再用。

A centrifugal pump for the disabled, it is necessary to pump and hose to motor-pumped wells, pumps and a net release of water hose. Then, in accordance with technical requirements, carefully check the water pump impeller, bearings, etc.口杯parts should be replaced if damaged. Wash bearings with gasoline, coated with butter, and then installed. At the end of the pump valves, cast iron pipe and other items to be rusty rust, and then coated with butter, dry place on the preservation, re-use for winter and spring.
Second, deep-well pump. Deep well pump, if not temporary, could be every 7 to 10 days to start running for half an hour, to prevent the motor, starter and other electrical equipment and pumps damp parts of the rotating die rust. If a longer time out, it should be made to pump from the wells to carry out maintenance, rust, coating for oil and parts, after assembly storage preservation.
Third, the motor. Not easy to damp the long-term motor, which should be removed Inoue, back indoors, the motor casing clean the dirt. Part of the movement of the intact condition, according to the technical requirements for inspection, if the parts wear, it is necessary to repair or for parts, to be consistent with the technical requirements, and then save storage. If short-term disabled, and in the motor starter, the blankets or plastic sheeting to catch the oil, do a good rain, moisture and dust and so on.
IV diesel engine. Summer rainy season, placed in the river, not the use of the diesel engine井旁to timely carried indoors. According to the technical requirements to conduct a thorough inspection, maintenance, change parts, oil coated, so that each part of the technical status intact. Elevate and then stored for winter use.

0

阅读 评论 收藏 转载 喜欢 打印举报/Report
  • 评论加载中,请稍候...
发评论

    发评论

    以上网友发言只代表其个人观点,不代表新浪网的观点或立场。

      

    新浪BLOG意见反馈留言板 电话:4000520066 提示音后按1键(按当地市话标准计费) 欢迎批评指正

    新浪简介 | About Sina | 广告服务 | 联系我们 | 招聘信息 | 网站律师 | SINA English | 会员注册 | 产品答疑

    新浪公司 版权所有